贝朗DIALOG透析机水路设计概览.ppt

,Titelmasterformat durch Klicken bearbeiten,Textmasterformate durch Klicken bearbeiten,Zweite Ebene,Dritte Ebene,Vierte Ebene,Fnfte Ebene,*,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,*,Authors:Guenter NissenHeiko Riemenschneider,文章内容来源于网络，如果侵权或者不当的地方，请联系我删除或者改正。文章内容仅可参考，不能作为科学依据。谢谢！,The content of this article comes from the Internet.If there is any infringement or improper place,please contact me to delete or correct it.The content of the article can only be referred to,not as a scientific basis.thank you!,Titelmasterformat durch Klicken bearbeiten,Textmasterformate durch Klicken bearbeiten,Zweite Ebene,Dritte Ebene,Vierte Ebene,Fnfte Ebene,*,*,文章内容来源于网络，如果侵权或者不当的地方，请联系我删除或者改正。文章内容仅可参考，不能作为科学依据。谢谢！,The content of this article comes from the Internet.If there is any infringement or improper place,please contact me to delete or correct it.The content of the article can only be referred to,not as a scientific basis.thank you!,29/10/2026,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,1,T,TSHE,Flow Diagram,水路图可分成六个节段：,1,、,进水节段,2,、,除气和加热节段,3,、,配比透析液节段,4,、,平衡腔容量控制节段,5,、,超滤控制节段,6,、,冲洗桥节段,29/10/2026,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,2,Water Inlet,Degassing and Heating,进水节段，除气和加热节段,进水口,排水口,T,TSHE,进水部分,DMV:减压阀,RVVB:进水电磁阀,WT:热交换器,VB:水箱,NSVB:水箱液位传感器,除气部分,RVE:除气比例阀,PE：除气压力传感器,EK：除气室,EP:除气泵,加热部分,TSHE:加热前温度传感器,H:加热棒,TSH:加热棒高温保护,TSE:加热后温度传感器,29/10/2026,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,3,Water Upline Tank,水箱,填充水箱，整个压力通路通畅,高水位触点,关闭进水阀门,低水位触点,自动停止加热,泵停转,中水位（低于高位触点）,打开进水阀门,注意：浮球上的,三角标识指示,装配方向,经除气和加热后的反渗水,反渗水,高水位限位圈,29/10/2026,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,4,去除气和加热,节段,经除气和加热后,的反渗水,除气和加热后的,反渗水,部分溢流至,3/2,部分,去配比透析液阶段,反渗水进水,Water Upline Tank,水箱,进水减压阀,控制进水箱反渗水,压力不高于,1.3Bar,29/10/2026,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,5,Dialysate Preparation,配比透析液节段,进水口,排水口,Bicconcentrate,B液,acidicconcentrate,A液,T,TSHE,1.3Bar,BICP:B液泵,RVB:B液单向阀,TSBIC:B液温度传感器,BICLF:B液电导度传感器,KP:A液泵,RVK:A液单向阀,ENDLF:总电导度传感器,ENDLF_S:ENDLF的检测信号,TSD:透析液温度传感器,TSD_S:TSD的检测信号,FPE:正压泵,RVFPE:FPE的高压保护阀,29/10/2026,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,6,Main Flow/Bypass,主水路,/,旁路,29/10/2026,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,7,Main Flow/Bypass,主水路,/,旁路,29/10/2026,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,8,Balance Chamber,平衡腔,透析液,dialyser,透析器,用后透析液+超滤液,FPE:正压泵,FPA:负压泵,BK1/2:平衡腔室1/2,MSBK1/2:平衡腔膜位移传感器,VEBK:透析液进平衡腔电磁阀,VDEBK:透析液出平衡腔电磁阀,VDABK:废液进平衡腔电磁阀,VABK:废液出平衡腔电磁阀,29/10/2026,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,9,Balance Chamber Phase 1,平衡腔容量平衡,1,阶段,正压泵,平衡腔,LA,(,空气分离室,),FPA(负压泵),UFP(超滤泵),BLD,PDA,DDE:透析液节流阀,RVDA:废液节流阀,PDA:废液压力传感器,BLD:漏血传感器,29/10/2026,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,10,Balance Chamber Phase 2,平衡腔容量平衡,2,阶段,正压泵,空气分离室,负压泵,超滤泵,平衡腔,BLD,PDA,29/10/2026,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,11,持续监测平衡腔膜片位置,持续控制,，腔体内压力稳定，阀门切换对流速影响小,透析器内没有压力突变,超滤平稳并且避免了平衡腔切换时产生反超,透析液持续不断（包括液流切换时刻）,维持住弥散压力可带来更好的治疗效果,(K*t/V,值,),对膜片、阀门和泵都有保护作用,延长配件寿命,Advantages of the Dialog Balance Chamber Control,Dialog,改良的,平衡腔控制系统的优点,Dialog,+,Wettbewerb,29/10/2026,Training document,no update service.This document may not be copied,partly or whole,or made be accessible to third parties without our permission and remains the property of B.Braun Medizintechnologie GmbH with all rights.,12,Main Flow/Bypass,主水路,/,旁路,(,安全性设计,),净的透析液,废液：,透析液+超滤液,通向除气部分,透析器,VBP:旁路阀,VDE:透析液出机器电磁阀,VDA:废液回机器电磁阀,LA:空气分离室,VLA:空气分离阀,Flow Diagram Disinfection,消毒循环回路,water inlet,dialysate outlet,消毒液,通大气软管,T,TSHE,VD:消毒阀,VZ:循环阀,29/10/2026,13,谢谢。,我的联系方法：,021-22163398,Bo.cui,29/10/2026,14,